Service
schedules 1987-1999Service
schedules 1999-2003Service
schedules 2003-2005 Range RoverService
schedules for off-road•What your Rover
needs... and when
Service
schedules 1987-1999
Service
schedules 1999-2003
Service
schedules 2003-2005 Range Rover
Service
schedules for off-road
LAND ROVER SERVICE
SCHEDULES:
1999 to 2003 Discovery II and 99-02 Range Rover models with Bosch engine
management
What should be done, and when: Note that this list of service differs in some
respects from the manufacturer service schedule. It is based upon our extensive
experience and intended for users who operate their trucks mostly on road, on
highway. Drivers who run extensively off road or in water may have different
needs. Drivers with modified trucks may also have different needs. This list is
intended to serve as a guide only.
Bosch Rovers do not have replaceable fuel filters. Other service tasks are simplified as compared to older Land Rover products.
| The Service Engine light comes on when there is a problem with the engine management system, the fuel evaporative control system, or the interface with the electronic transmission controls. You can check and clear codes with an OBD II scan tool after performing the necessary repairs. |
|
3,000 - 3,250 miles if using non-synthetic oil * not recommended * |
|
| Change oil and filter if you're using regular oil. Less often and you'll be building up sludge in the motor. | |
|
7,500 mile intervals between major services |
|
|
§ Change oil & filter using good synthetic oil. We recommend Mobil 1 Extended Performance. § Check and top all other fluids § Rotate tires § Check for damage under car § Grease drive shaft u-joints § Lube body hinges and door latches § We suggest you check your tires carefully. The Goodyear and Michelin tires will wear longer if rotated every 7,500 miles. Some other tires can be left alone for 15,000 miles |
|
|
15,000 miles |
|
|
1. Change engine oil filter. We recommend Mobil 1 Extended Performance. 2. Check and top all other fluids 3. Remove wheels, inspect steering, suspension, and brakes. Rotate tires and make sure lugs are lubricated and hubs are corrosion free. 4. Check lights and wiper/washer system 5. Check belts and hoses, and check for leaks and/or damage. 6. Check accessories for proper function. 7. Road test and check for other problems |
|
|
30,000 miles or 3 years |
|
|
1. Change engine oil & filter. We recommend Mobil 1 Extended Performance. 2. Drain and refill transmission fluid 3. Check front and rear axle oils 4. Check (Discovery) or change (Range Rover) transfer case oil 5. Change brake fluid by pumping fresh fluid through the system. You will need the Autologic or similar Land Rover test system to operate the ABS pump to do this properly. 6. Change Dex-Cool coolant if more than 2 years old. Pay particular attention to leaks. 7. Check and top all other fluids 8. Oil all door and body hinges 9. Replace air filter |
10. Test battery and replace if faulty 11. Replace cabin filters if needed (Range Rovers) 12. Check steering linkage joints. Joints should all be good and tight. 13. Check brakes 14. Adjust parking brake 15. Check exhaust and under car components for damage 16. Replace wipers if torn or streaking 17. Check function of all lights 18. Check a/c and heat 19. Check all accessories 20. Check washer jets, clean and adjust if needed 21. Rotate tires 22. Check for stored fault conditions with Autologic or T4 system 23. Road test and note other problems |
|
45,000 miles |
|
|
1. Change engine oil & filter. We recommend Mobil 1 Extended Performance 2. Check transmission fluid 3. Check front and rear axle oils 4. Check swivel housings 5. Check transfer case oil 6. Check and top all other fluids 7. Oil all door and body hinges 8. Grease drive shaft joints 9. Clean air filter |
10. Check steering linkage joints. Joints should all be good and tight. 11. Check brakes 12. Check exhaust and under-car components for damage 13. Replace wipers if bad 14. Check lights 15. Check a/c and heat 16. Check all accessories 17. Check washer jets, clean and adjust if needed 18. Rotate tires 19. Road test and note other problems |
| 60,000 miles | |
|
1. Change engine oil & filter. We recommend Mobil 1 Extended Performance. 2. Change transmission fluid 3. Change front and rear axle oils * Land Rover recommends this service at 90,000 miles in the US. We suggest 60,000 miles if you use your vehicle to two or go off-roading. 4. Change Dex-cool coolant 5. Replace plastic fill plug on radiator if fitted 6. Change transfer case oil 7. Change brake fluid by pumping fresh fluid through the system. You will need the Autologic or similar Land Rover test system to operate the ABS pump to do this properly. 8. Check and top all other fluids 9. Test battery and replace if faulty |
10. Oil all door and body hinges 11. Grease drive shaft joints 12. Replace platinum spark plugs 13. Replace air filter 14. Clean throttle body 15. Clean differential vent pipes 16. Check steering linkage joints 17. Check brakes 18. Adjust parking brake 19. Check exhaust and under car components for damage 20. Replace wipers if bad 21. Check lights 22. Check a/c and heat 23. Check all accessories 24. Check washer jets, clean and adjust if needed 25. Rotate tires 26. Check for stored fault conditions with Autologic or Testbook 27. Check operation of O2 sensors and emission system if not done at 52,500 28. Road test and note other problems |
|
75,000 miles |
|
|
1. Change engine oil filter. We recommend Mobil 1 Extended Performance. 2. Check transmission fluid 3. Check front and rear axle oils 4. Check and top all other fluids 5. Check swivel housings 6. Check transfer case oil 7. Oil all door and body hinges 8. Grease drive shaft joints 9. Clean air filter |
10. Check steering linkage joints. Joints should all be good and tight. 11. Check brakes 12. Check exhaust and under car components for damage 13. Replace wipers if bad 14. Check lights 15. Check a/c and heat 16. Check all accessories 17. Check washer jets, clean and adjust if needed 18. Rotate tires 19. Road test and note other problems |
|
90,000 miles |
|
|
1. Change engine oil & filter. We recommend Mobil 1 Extended Performance. 2. Change transmission fluid and filter 3. Change front and rear axle oils if not changed at 60k. If changed at 60k, check at 90k. 4. Change Dex-cool coolant. 5. Change transfer case oil 6. Change brake fluid by pumping fresh fluid through the system. You will need the Autologic or similar Land Rover test system to operate the ABS pump to do this properly. 7. Check and top all other fluids 8. Oil all door and body hinges 9. Grease drive shaft joints 10. Test battery and replace if faulty |
11. Check hubs for looseness and noise – at this mileage they will begin to fail. 12. Replace air filter 13. Check steering linkage joints. 14. Check brakes 15. Adjust parking brake 16. Check exhaust and under car components for damage 17. Replace wipers if bad 18. Check lights 19. Check a/c and heat 20. Check all accessories 21. Check washer jets, clean and adjust if needed 22. Rotate tires 23. Check for stored fault conditions with Autologic or Testbook 24. Check operation of O2 sensors, replace if bad 25. Road test and note other problems |
|
105,000 miles |
|
|
1. Change engine oil filter. We recommend Mobil 1 Extended Performance. 2. Check transmission fluid. Check steering linkage joints. Joints should all be good and tight. 3. Check brakes 4. Check exhaust and under car components for damage 5. Replace wipers if bad 6. Check lights 7. Check a/c and heat 8. Check all accessories 9. Check washer jets, clean and adjust if needed 10. Rotate tires 11. Road test and note other problems. Check front and rear axle oils. 12. Check and top all other fluids |
13. Check swivel housings 14. Check transfer case oil 15. Oil all door and body hinges 16. Grease drive shaft joints 17. Replace spark plugs 18. Clean air filter 19. Check steering linkage joints. Joints should all be good and tight. 20. Check brakes 21. Check exhaust and under car components for damage 22. Replace wipers if bad 23. Check lights 24. Check a/c and heat 25. Check all accessories 26. Check washer jets, clean and adjust if needed 27. Rotate tires 28. Road test and note other problems |
|
120,000 miles |
|
|
1. Change engine oil filter. We recommend Mobil 1 Extended Performance. 2. Change transmission fluid 3. Change front and rear axle oils 4. Change Dex-cool coolant 5. Replace plastic fill plug on radiator if fitted 6. Change transfer case oil 7. Change brake fluid by pumping fresh fluid through the system. You will need the Autologic or similar Land Rover test system to operate the ABS pump to do this properly. 8. Check and top all other fluids 9. Test battery and replace if faulty 10. Oil all door and body hinges |
11. Grease drive shaft joints 12. Replace platinum spark plugs 13. Replace air filter 14. Check steering linkage joints. 15. Check brakes 16. Adjust parking brake 17. Check exhaust and under car components for damage 18. Replace wipers if bad 19. Check lights 20. Check a/c and heat 21. Check all accessories 22. Check washer jets, clean and adjust if needed 23. Rotate tires 24. Check for stored fault conditions with Autologic or Testbook 25. Replace O2 sensors unless they've already been changed 26. Road test and note other problems |